Furnace Repair Services in Maple Glen, PA
- Locally Owned & Operated
- Trust & Transparency
- Long-Term Relationships
A lot of Maple Glen homes now heat with two things at once. A heat pump handles the milder half of winter and a gas or propane furnace takes over when it gets cold, and a control somewhere decides which one runs. When that decision is set wrong, the house stays comfortable and the fuel bill quietly goes up.
Davis Modern Heating & Cooling services dual fuel systems, straight furnaces, and heat pumps across Maple Glen and Upper Dublin Township. We have been family owned since 1850 and we work on every brand across all fuel types.
Our Services
- Boiler Installation & Replacement
- Boiler Maintenance
- Boiler Repair
- Furnace Installation & Replacement
- Furnace Maintenance
- Furnace Repair
- Geothermal Heat Pump Installation & Repair
- Heat Pump Installation & Replacement
- Heat Pump Maintenance
- Heat Pump Repair
- Oil Furnace Repair & Maintenance
- Convert From Oil Heat
- Radiant Floor Heating Installation & Repair
- Tankless Water Heater Installation & Repair
- Water Heater Repair
- Water Heater Replacement & Installation
Contact Us
- This site is protected by reCAPTCHA
Heating Behavior That Needs a Closer Look
Dual fuel systems fail in ways a single system does not. These are the signs.
- Furnace running in mild weather
- Heat pump running in extreme cold
- Auxiliary heat always on
- Cool air during a heating cycle
- Loud clunk at changeover
- Outdoor unit iced over
- Fuel use higher than expected
- System switching constantly
- Thermostat showing an alert
- Any burning smell
Several of these point to settings rather than broken parts, which is usually good news.
Dual Fuel Systems and the Changeover Point
The changeover point is the heart of a dual fuel system. Below a certain outdoor temperature the heat pump becomes less economical than the furnace, and above it the opposite is true. That balance point depends on the house, the equipment, and current fuel and electric costs, and it is frequently left at whatever the installer typed in years ago.
Set too high, the furnace runs on mild days when the heat pump would have been cheaper. Set too low, the heat pump struggles in cold weather and auxiliary heat picks up the difference, which is the most expensive way to warm a house. Neither situation feels like a malfunction from inside the home.
Defrost is the other regular complaint. A heat pump in cold weather periodically reverses to clear frost from the outdoor coil, and during that cycle the indoor air can feel cool while the outdoor unit steams. It looks alarming and it is normal. What is not normal is a defrost cycle that runs constantly or never completes, and that needs diagnosis.
Furnace and Heat Pump Service Together
We repair and service furnaces, heat pumps, dual fuel systems, boilers, oil furnaces, thermostats, zone controls, ductwork, and ventilation on every brand. Working comfortably on both sides of a dual fuel system is not optional in this area, since so many homes have one.
A heating call covers ignition and flame sensing, fuel pressure, blower performance, safety controls, venting, temperature rise, and heat exchanger inspection on the furnace side. On the heat pump side it covers refrigerant pressures, reversing valve operation, defrost control, sensors, and auxiliary heat staging. We also verify the changeover settings, which almost nobody checks.
If equipment needs replacing, we explain how we got there and lay out options across electric, natural gas, propane, and heating oil. We also bring more than thirty five years of experience with geothermal heat pumps.
A Changeover Problem in Maple Glen
Brian called from Maple Glen in January because his heating bills had climbed sharply even though the house felt fine and nothing seemed broken.
Our technician found the changeover point set far higher than it needed to be, which meant the furnace was carrying almost the entire winter while the heat pump sat idle, and auxiliary heat staging set to engage earlier than necessary. We corrected both settings, verified the system switched cleanly in both directions, and cleaned the burners and flame sensor while on site.
The house stayed just as comfortable and the following month's usage dropped noticeably. It is one of the few heating calls where the fix is entirely in the settings and the result shows up on a bill rather than on a thermostat.
Why Maple Glen Keeps Calling Us
Here is what keeps households in this area calling us.
- Family owned since 1850
- Dual fuel and heat pump expertise
- All brands and fuels serviced
- Around the clock on-call service
- Licensed in Pennsylvania
- Changeover settings verified
- Findings shown, not just described
- Geothermal and solar experience
Our on-call technicians are reachable at any hour, so a failure on a February night is handled that night rather than added to a list.
Frequently Asked Questions
What is a dual fuel system?
It pairs a heat pump with a fossil fuel furnace and switches between them based on outdoor temperature, using whichever is more economical at the time.
Why does my heat pump blow cool air sometimes?
Most often during a defrost cycle, which is normal. Frequent or incomplete defrost cycles are not, and those should be checked.
Is emergency heating service available?
Yes. We have technicians on call 24 hours a day, seven days a week.
How do I know if my changeover point is set correctly?
It should reflect your equipment, your house, and current fuel and electric costs. We verify it during service, and it is often left at a default.
Do heat pumps need service in winter?
Yes. They run year round, so they accumulate far more hours than a cooling only system and benefit from service in both seasons.